了解锅炉的保养使用就会长久了! - 山东多介质过滤器哪家好
欢迎光临!888贵宾会网站登录网址,主营:山东燃气锅炉山东电采暖锅炉山东多介质过滤器和射线防护器材等。
  • 服务热线:18678809986
  • 888贵宾会网站登录网址 关于我们 产品中心 888贵宾会手机版 工程案例 设备选型 联系我们
  • 您的位置:888贵宾会网站登录网址> 888贵宾会手机版 >

    了解锅炉的保养使用就会长久了!
    来源: 发布时间:2020-09-15

    方法一:烘干法
    Method 1: drying method
    此法就是在停炉时,当锅炉水的温度降至100~120℃时,进行放水.当水放尽后,利用炉内余热,点微火或引入炉膛热风,将锅炉内表面烘干。
    This method is to discharge water when the temperature of boiler water drops to 100-120 ℃ when the boiler is shut down. When the water is exhausted, the boiler inner surface is dried by using the residual heat in the furnace, igniting a slight fire or introducing hot air into the furnace.
    方法二:燥剂法:
    Method 2: drying agent method
    干燥剂法就是在锅炉停用后,当锅炉水的温度降至100~120℃时,将锅炉内的水放掉,利用炉内余热,将金属表面烘干,并清理沉积在锅炉水系统内的水垢和水渣.然后在锅炉内放入干燥剂,保持金属表面干燥,不让腐蚀.常用的干燥剂有:无水氯化钙、生石灰、硅胶.
    The desiccant method is to drain the water in the boiler when the temperature of the boiler water drops to 100 ~ 120 ℃ after the boiler is out of service. The metal surface is dried by using the residual heat in the furnace, and the scale and water slag deposited in the boiler water system are cleaned up. Then the desiccant is put into the boiler to keep the metal surface dry without corrosion. The commonly used desiccants are: anhydrous calcium chloride, quicklime and silica gel
    方法三:湿法保养
    Method 3: wet maintenance
    湿法保养一般适用于停炉时间不超过一个月的锅炉的保养。停炉后按规定时间放尽炉水,将水垢、水渣、烟灰清理干净。
    Wet maintenance is generally applicable to the maintenance of boilers whose shutdown time is less than one month. After the boiler is shut down, the boiler water shall be drained according to the specified time, and the scale, water slag and ash shall be cleaned up.
     山东燃气锅炉
    方法四:压力保养
    Method 4: pressure maintenance
    新乡燃油燃气锅炉厂家认为适用于生产备用锅炉或停运进行短暂检修时间不超过一周的锅炉。停炉后把炉水放尽,将炉内的水垢、水渣清理干净,重新加入合格软化水。
    Xinxiang oil and gas-fired boiler manufacturers believe that it is suitable for production of standby boilers or boilers that are out of service for a short period of time less than one week. After shutdown, drain the boiler water, clean up the scale and water slag in the furnace, and add qualified softened water again.
    定期用小火加热,或定期利用相邻锅炉的蒸汽加热炉水,使锅炉内的炉水温度夏季应保持在环境温度+10℃左右,冬季应使炉水不冻结 ,关闭放空阀、排污阀和放水阀,不让漏水。
    Heat the boiler water regularly with small fire or steam from adjacent boilers to keep the boiler water temperature in the boiler at + 10 ℃ in summer and keep the boiler water from freezing in winter. Close the vent valve, drain valve and drain valve to prevent water leakage.
    方法五:热法
    Method 5: thermal method
    此法用于停炉时间在10天以内. 方法是在汽包上方安装一个水箱,用管子和汽包相联通.锅炉停用后,充满除过氧的水,水箱中大半充满着水.水箱用外来蒸汽通入加热,使水箱中水经常保持沸腾状态.所述做好课后及时复习的要点适用于本环节外,还必须注意以下几点:
    This method is used to stop the boiler within 10 days. The method is to install a water tank above the drum and connect the pipe with the drum. After the boiler is shut down, it is filled with water excluding peroxide, and most of the water tank is full of water. The water tank is heated by external steam to keep the water in boiling state. The key points of timely review after class are applicable to this link, and the following points must be paid attention to:
    感谢您的阅读,此文的文章来源: 山东燃气锅炉更多的内容和问题请点击:我们会继续努力的为您提供服务,感谢您的支持!
    Thank you for your reading. This article is from Shandong gas fired boiler. For more information and questions, please click: We will continue to work hard to provide services for you, thank you for your support!

    鲁公网安备 37011302000227号