生物质加热锅炉燃烧效率的提高方法! - 山东多介质过滤器哪家好
欢迎光临!888贵宾会网站登录网址,主营:山东燃气锅炉山东电采暖锅炉山东多介质过滤器和射线防护器材等。
  • 服务热线:18678809986
  • 888贵宾会网站登录网址 关于我们 产品中心 888贵宾会手机版 工程案例 设备选型 联系我们
  • 您的位置:888贵宾会网站登录网址> 888贵宾会手机版 >

    生物质加热锅炉燃烧效率的提高方法!
    来源: 发布时间:2020-01-03

      国家节能政策的影响下,加热锅炉一般使用生物质燃料,生物质加热锅炉生物质颗粒燃料的气化提供集中供暖锅炉、生物质能源能力远远超过总能量需求,相当于世界上10倍的能源消耗,因此冬天使用生物质加热锅炉具有十分重要的意义。
      Under the influence of national energy-saving policy, biomass fuel is generally used in heating boilers. The gasification of biomass pellet fuel in biomass heating boilers provides central heating boilers, and the biomass energy capacity far exceeds the total energy demand, which is equivalent to 10 times of the world's energy consumption. Therefore, it is of great significance to use biomass heating boilers in winter.
      为了使锅炉节能效果,需要增加生物质加热锅炉燃烧效率,以及其他锅炉,提高生物质加热锅炉燃烧效率,需要保护炉内结渣,保证锅炉燃烧速度快的同时,向你们介绍以下提高生物质加热锅炉燃烧效率的措施:
      In order to achieve the energy-saving effect of the boiler, it is necessary to increase the combustion efficiency of the biomass heating boiler and other boilers, improve the combustion efficiency of the biomass heating boiler, protect the slagging in the furnace, and ensure the fast combustion speed of the boiler. At the same time, the following measures to improve the combustion efficiency of the biomass heating boiler are introduced to you:
      1. 充氧:过量空气系数过小,即供气量不足,会增加固体q4不完全燃烧的热损失和可燃气体q3不完全燃烧的热损失,从而降低燃烧效率;如果过量空气系数过大,会降低炉温,增加不完全燃烧的热损失。过剩的空气系数使得q2+q3+q4 *的总和很小。
    山东燃气锅炉
      1. Oxygen charging: if the excess air coefficient is too small, i.e. insufficient air supply, it will increase the heat loss of incomplete combustion of solid Q4 and combustible Q3, thus reducing the combustion efficiency; if the excess air coefficient is too large, it will reduce the furnace temperature and increase the heat loss of incomplete combustion. The excess air factor makes the sum of Q2 + Q3 + Q4 * very small.
      2. 防结垢除垢技术:通过使用生物质加热锅炉除垢剂和电子防垢器,优化水蒸汽循环系统,合理控制锅炉排污率,从而降低结垢,提高锅炉热效率。
      2. antiscale and descaling technology: through the use of biomass heating boiler descaling agent and electronic antiscale device, optimize the water steam circulation system, reasonably control the boiler blowdown rate, so as to reduce fouling and improve the boiler thermal efficiency.
      3.保持生物质加热锅炉燃料的合理火焰前沿位置。火焰前端应位于炉排与中间炉排之间的区域。
      3. Keep the reasonable flame front position of biomass heating boiler fuel. The front end of the flame shall be located in the area between the grate and the intermediate grate.
      

    鲁公网安备 37011302000227号